Update: Allograft-Associated Bacterial Infections --- United States, 2002

Tissue allografts are commonly used in orthopedic surgical procedures; in 1999, approximately 650,000 musculoskeletal allografts were distributed by tissue processors (1). A rare complication of musculoskeletal allografts is bacterial infection (2,3). After the reported death of a recipient of an allograft contaminated with Clostridium spp. (an anaerobic spore and toxin-forming organism) (3), CDC investigated this case and solicited additional reports of allograft-associated infections; 26 cases have been identified. This report summarizes the investigation of these cases and describes additional steps given to a tissue processor to enhance tissue transplant safety.

On November 7, 2001, a man aged 23 years underwent reconstructive knee surgery at a hospital in Minnesota using a femoral condyle (bone-cartilage) allograft. On November 10, he developed pain at the surgical site, which rapidly progressed to shock; the patient died the following day (3). Blood cultures obtained premortem grew Clostridium sordellii.

On November 13, a man aged 17 years underwent reconstructive knee surgery in Illinois using a femoral condyle (fresh) and a meniscus (frozen). The next day, the patient developed fever, which did not respond to first-generation cephalosporin antibiotics. Eight days after surgery, he was admitted to a local hospital for septic arthritis; his temperature on admission was 103.5^o F (39.7^o C). The patient received ampicillin-sulbactam, and the fever subsided within 24 hours. The patient is recovering. Cultures for anaerobic bacteria, including C. sordellii, were not obtained.

The three allografts received by these two patients came from the same cadaveric donor (donor A) and were supplied by tissue processor A (TP-A). Based on records from the medical examiner, no evidence indicated that donor A was septic or had risk factors for Clostridium spp. infection (e.g., injecting drug use or abdominal trauma). The body of donor A was refrigerated 19 hours after death; tissue was procured 23.5 hours after death. One tissue-procurement organization recovered the tissue and sent all tissue to TP-A for processing.

Including the two cases described above, 10 tissues from donor A were transplanted into nine patients located in eight states. No additional infections were identified. CDC obtained 19 nonimplanted tissues from donor A and identified C. sordellii in two tissues (fresh femoral condyle and frozen meniscus) and from the fluid bathing the tissues.

TP-A used aseptic processing of harvested tissues. Companion tissue (e.g., a sliver of cartilage from a femoral condyle) was processed alongside the allograft. After suspension of the allograft and companion tissue in an antibiotic/antifungal solution, the companion tissue was cultured. The aerobic and anaerobic cultures of the companion tissues from donor A were reported as negative at TP-A. No other cultures were taken before tissue processing. No swab cultures were taken; all cultures were destructive (i.e., performed on tissue that had been ground up).

To identify additional cases of allograft-associated infections, CDC solicited case reports through electronic listservers and MMWR (2,3) and by contacting the Food and Drug Administration (FDA) and state regulatory authorities (2). A case of allograft-associated infection was defined as any surgical site infection (SSI) at the site of allograft implantation occurring within 12 months of allograft implantation in an otherwise healthy patient with no known risk factors for SSI (e.g., diabetes). Cases could be culture-negative if diagnosed by infectious diseases physicians or surgeons and diagnostic (e.g., knee aspirate) or operative findings supported SSI diagnosis. If only Staphylococcus aureus or Staphylococcus spp. were isolated, patients were excluded unless additional epidemiologic or microbiologic evidence suggested allograft contamination.

As of March 11, 2002, CDC has received 26 reports of bacterial infections associated with musculoskeletal tissue allografts including the previously reported cases (2,3). Thirteen (50%) of the 26 patients were infected with Clostridium spp. (C. septicum [12], C. sordellii [one]); 11 (85%) of these patients received tissue processed by TP-A. Allografts that were implicated in Clostridium spp. infections were tendons used for anterior cruciate ligament (ACL) reconstruction (eight), femoral condyles (two), bone (two), and meniscus (one). Eleven (85%) of the allografts were frozen and two (15%) were fresh (femoral condyles). All allografts were processed aseptically but did not undergo terminal sterilization. In 11 of these 13 cases, additional evidence (e.g., common donors or cultures of nonimplanted tissue) implicated the allograft as the source of the infection. CDC has requested additional information for the other two cases. The median age of these 13 patients was 35 years (range: 15--52 years); onset of symptoms occurred at a median of 8.5 days (range: 2--85 days) following allograft implantation. One patient died.

Eleven patients were infected with gram-negative bacilli; five had polymicrobial infection. Cultures from two patients were negative: the Illinois patient and a patient with necrotizing soft tissue infection treated with multiple debridements, hyperbaric oxygen, and intravenous antibiotics that covered anaerobes. The transplanted tissues included ACL (10), femoral condyle (one), meniscus (one), and bone (one). One tissue was fresh (femoral condyle), one was freeze dried (bone), and the rest were frozen. For eight (62%) of these 13 cases, additional evidence implicated the allograft (e.g., common donors or positive pre-implantation or processing cultures with matching microorganisms) (2). CDC continues to investigate these cases. Eight patients received allografts that had undergone aseptic processing but no terminal sterilization. Three patients received allografts that were reported to have undergone gamma irradiation.

In response to the initial case investigation and the subsequent reports of Clostridium spp. infections, CDC provided to TP-A some additional steps to reduce the risk for allograft associated infections.

When possible, a method that can kill bacterial spores should be used to process tissue. Existing sterilization technologies used for tissue allografts such as gamma irradiation, or new technologies effective against bacterial spores should be considered. Unless a sporicidal method is used, aseptically processed tissue should not be considered sterile, and health-care providers should be informed of the possible risk for bacterial infection.

If no sporicidal method is available (e.g., for certain tissues such as fresh femoral condyles), efforts should be made to minimize the potential for Clostridium spp. and other bacterial contamination. First, tissue should be cultured before suspension in antimicrobial solutions (4), and if Clostridium spp. or other bowel flora are isolated, all tissue from that donor that cannot be sterilized should be discarded. Second, culture methods should be validated to ensure that residual antimicrobials do not result in false negative culture results (5). Performing both destructive and swab cultures should be considered. Third, recommended time limits for tissue retrieval should be followed (4).

After receiving a report of potential allograft-associated infection, remaining tissue from that donor should not be released until it is determined that the allograft is not the source of infection (4). Tissue processors should contact health-care providers of recipients of tissue from the same donor implicated in an allograft-associated infection. In these cases, a sample of nonimplanted tissues that underwent the same processing method should be cultured by an independent laboratory using a validated method. CDC has recommended that TP-A perform a one-time audit of its unreleased tissue inventory to estimate the proportion of unreleased tissue that might be contaminated with microorganisms or spores.

Reported by: LK Archibald MD, DB Jernigan MD, Div of Healthcare Quality Promotion, National Center for Infectious Diseases; MA Kainer, MD, EIS Officer, CDC.

Editorial Note:

Tissue allografts can improve substantially the quality of life for many patients. However, infections associated with bacterial contamination of allografts can result in serious morbidity and death (2,3). As of March 11, 26 patients with allograft-associated infections have been identified: 13 with Clostridium spp. infection and 14 associated with a single tissue processor. The findings in this report have important implications for patient safety and indicate that current federal regulations and industry standards on processing and quality control methods need to be enhanced and implemented to prevent Clostridium spp. and other allograft-associated infections.

At CDC, destructive cultures of nonimplanted tissues from donor A were positive for C. sordellii. In contrast, destructive cultures of the companion tissue from donor A were reported to be negative at TP-A. Two factors might explain this discrepancy. First, because tissues were cultured at TP-A only after suspension in the antibiotic/antifungal solution, residual antibiotics on the tissues might have caused a false-negative culture result because of bacteriostasis. Second, cultures of the smaller companion tissues might not have been representative of the allografts. Although American Association of Tissue Banks standards recommend that cultures be obtained before and after processing, these standards do not address the potential problem of bacteriostasis after processing or specify a culture method (4). Although destructive cultures used by TP-A are very sensitive, a combination of swab and destructive cultures would be most sensitive in detecting bacterial contamination (6).

Donor A tissue probably became hematogenously seeded by bowel flora, including Clostridium spp., before harvesting (7). Factors that may contribute to contamination with bowel flora include time interval between death and tissue retrieval and delays in refrigeration and mode of death (e.g., trauma) (7). Aseptic processing does not eradicate contamination with organisms (2), and antibiotic/antifungal solutions will not eliminate spores of organisms such as Clostridium spp.

Sterilization of tissue that does not adversely affect the functioning of tissue when transplanted into patients is the best way to reduce the risk for allograft-associated infections. However, two sterilization methods (ethylene oxide and gamma irradiation) that would eliminate spores have associated technical problems that limit their use in processing of tissues for transplantation (2). New low-temperature chemical sterilization technologies that kill spores (8) but preserve the biomechanical integrity and function of some allografts are being evaluated (9,10).

FDA regulations state that each tissue bank is required to have written procedures for prevention of infectious disease contamination or cross-contamination by tissue during processing. In response to these cases reports, FDA has released new guidelines for tissue processors (http://www.fda.gov/cber/guidelines.htm#tissval).

CDC, in collaboration with state health departments, tissue processors, and clinicians, continues to solicit and investigate case reports to identify risk factors associated with acquisition of infection following receipt of an allograft. When septic arthritis occurs after use of an allograft, contamination should be suspected, and diagnostic work-up should include obtaining anaerobic cultures. Clinicians should consider expanding empiric antibiotic therapy to include agents effective against gram-negative organisms and anaerobes. Clinicians should report infections involving allograft tissue to tissue processors, FDA's Medwatch System, and CDC, telephone (800) 893-0485. 

Acknowledgements

This report is based on data contributed by JC Davis, MD, Alabama Sportsmedicine and Orthopedic Center, Birmingham, Alabama. SA Barbour, MD, Warren King Sports Medicine Fellowship; W King, MD, Palo Alto Medical Foundation, Palo Alto, California; J Rosenberg, MD, Div of Communicable Disease Control, California Dept of Health Svcs. DC Bartley, MD, St Vincents Medical Center, Jacksonville; D Dodson, MD, West Palm Beach; JM Malecki, MD, Palm Beach County Health Dept; AC Morse, Div of Sports Medicine, Florida Orthopedic Institute, Tampa; OV Martinez, PhD, Univ of Miami, Miami; S Wiersma, MD, Florida Dept of Health. HJ Cohen, MD, Northside Hospital; G Cierney III, MD, St Joseph's Hospital; MA Blass, MD, Georgia Infectious Diseases; EW Carson, MD, Resurgens Orthopaedics; DL Dickensheets, MD, JC Garrett, MD, Atlanta, Georgia. DJ Raab, MD, Illinois Bone and Joint Institute, Des Plaines; MJ Joyce, MD, American Academy of Orthopaedic Surgeons, Rosemont, Illinois. T Tibbot, Indiana Cardiac Retrieval, New Haven, Indiana. B Lutz, MD, Memorial Medical Center-Baptist Campus, New Orleans; R Ratard, MD, Lousiana Dept of Health and Hospitals. BS Wolock MD, Orthopedic Associates, Towson office, Baltimore; RJ Brechner, MD, Maryland Dept of Health and Mental Hygiene. SM Mulawka, MD, DJ Whitlock, MD, SJ Petrowski, MF Buhl, St. Cloud Hospital, St. Cloud; PM Hoeft, MD, Rice Memorial Hospital, Willmar; KH LeDell, MPH, R Lynfield, MD, RN Danila, PhD, HF Hull, MD, Minnesota Dept of Health. EA Bresnitz, MD, New Jersey Dept of Health and Senior Svcs. SG Jenkins, PhD, Mt Sinai Medical Center, New York; J Linden, MD, Blood and Tissue Resources, New York State Dept of Health. D Perrotta, PhD, Texas Dept of Health. DA Deneka, MD, Middle Tennessee Orthopedics and Sports Medicine, Murfreesboro; TF Jones, MD, AS Craig, MD, Tennessee Dept of Health. J Mowe, SH Doppelt, MD, RE Stevenson, PhD, American Association of Tissue Banks, McLean, Virginia. RD Noyce, MD, Midelfort Clinic, Eau Claire; TA Israel, MD, Sports Medicine, Luther/Midelfort, Mayo Health Systems, Eau Claire; JP Davis, MD, Wisconsin Div of Public Health. BJ Jensen, MS, MJ Arduino, DrPH, DN Whaley, HT Holmes, PhD, Div of Healthcare Quality Promotion, National Center for Infectious Diseases; DL Kirschke MD, ML Castor MD, EIS officers, CDC.

References

1. U.S. Census Bureau. Statistical Abstract of the United States 2001, No. 168 Organ Transplants and Grafts, 1990 to 2000. Available at http://www.census.gov/prod/2002pubs/01statab/health.pdf. Accessed March 2002.
2. CDC. Septic arthritis following anterior cruciate ligament reconstruction using tendon allografts---Florida and Louisiana, 2000. MMWR 2001;50:1081--3.
3. CDC. Update: Unexplained deaths following knee surgery---Minnesota, 2001. MMWR 2001;50:1080.
4. Woll JE, Kasprisin D. Standards for Tissue Banking. McLean, Virginia: American Association of Tissue Banks, 2001.
5. United States Pharmacopeia XXV. Chapter 71 Sterility Tests. Rockville, Maryland: The United States Pharmacopeial Convention, Inc. 2001:1878--83.
6. Mills AR, Roberts MR. Evaluation of culturing methods at predicting allograft sterility for aseptically processed tissue. Proceedings of the 25th Annual Meeting of the American Association of Tissue Banks, Washington DC, August 25--29, 2001.
7. Martinez OV, Malinin TI. The effect of postmortem interval and manner of death on blood and bone marrow cultures from non-septic cadaver donors of tissues for transplantation. Abstracts of the 96th Meeting of the American Society for Microbiology, New Orleans, Louisiana, 1996.
8. Wang JC, Kopf PK, Scurti G, Roberts M, Bianchi JR. Batch processed allograft bone versus single donor processing for antimicrobial capacity. Proceedings of the 29th Annual Meeting of the Cervical Spine Research Society. Monterey, California, 2001.
9. Summitt MC, Bianchi JR, Keesling JE, Roberts M, Mills CR. Mechanical Evaluation of soft tissue treated through a new tissue cleaning process. Proceedings of the 25th Annual Meeting of the American Association of Tissue Banks, Washington DC, August 25--29, 2001.
10. Summitt MC, Bianchi JR, Keesling JE, Roberts M, Mills CR. Biomechanical testing of bone treated through a new tissue cleaning process Proceedings of the 25th Annual Meeting of the American Association of Tissue Banks, Washington DC, August 25--29, 2001.

Use of trade names and commercial sources is for identification only and does not imply endorsement by the U.S. Department of Health and Human Services. References to non-CDC sites on the Internet are provided as a service to MMWR readers and do not constitute or imply endorsement of these organizations or their programs by CDC or the U.S. Department of Health and Human Services. CDC is not responsible for the content of pages found at these sites.

Disclaimer   All MMWR HTML versions of articles are electronic conversions from ASCII text into HTML. This conversion may have resulted in character translation or format errors in the HTML version. Users should not rely on this HTML document, but are referred to the electronic PDF version and/or the original MMWR paper copy for the official text, figures, and tables. An original paper copy of this issue can be obtained from the Superintendent of Documents, U.S. Government Printing Office (GPO), Washington, DC 20402-9371; telephone: (202) 512-1800. Contact GPO for current prices.

Page converted: 3/14/2002

Print Help MMWR Home | MMWR Search | Help | Contact Us CDC Home | Search | Health Topics A-Z

This page last reviewed 3/14/2002

Centers for Disease Control and Prevention
Morbidity and Mortality Weekly Report